compressive strength of concrete made with quarry dust

  • Use of Quarry Dust to Replace Sand in Concrete – An ...

    strength of concrete when replacing sand by quarry dust from 0% to in steps of 10%. M20 and M25 grades of concrete were taken for study keeping a constant slump of 60mm. The compressive strength of concrete cubes at the age of 7 and 28 days were …

    Get Price
  • Comparing the Compressive Strengths of Concrete Made with ...

    This work is focused on the use of quarry dust as a total replacement to river sand in the production of concrete, and comparing the results (compressive strength) to that obtained from conversional concrete made with river sand

    Get Price
  • Strength and durability properties of concrete containing ...

    has also been made to durability studies on Quarry Rock Dust when compared with the Natural Sand concrete. It is found that the compressive, flexural strength and Durability Studies of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete. Keywords: concrete, quarry rock dust, river sand, strength, properties ...

    Get Price
  • COMPARING THE COMPRESSIVE AND FLEXURAL STRENGTH OF ...

    home building technology comparing the compressive and flexural strength of concrete made with river sand and quarry dust as fine aggregate ...

    Get Price
  • Study on Compressive Strength of Quarry Dust as Fine ...

    (c) The compressive strength results of quarry dust concrete (cubes) were obtained in the third series, where M20, M25, and M30 grades of concrete with 20, 25, and 30 percent replacement of quarry dust and also workability are studied by varying the water-cement ratio …

    Get Price
  • Quarry Dust as a Partial Replacement of Coarse Aggregates ...

    Abstract: This study is an attempt to investigate the suitability of quarry dust as a partial replacement of coarse aggregates in concrete making. Samples of concrete cubes were made with varying proportions of quarry dust replacing the coarse aggregate. It was foreseen that the utilization of quarry …

    Get Price
  • COMPARING THE COMPRESSIVE STRENGTHS OF CONCRETE …

    This work is focused on the use of quarry dust as a total replacement to river sand in the production of concrete, and comparing the results (compressive strength) to that obtained from conventional concrete made with river sand. Key word: Quarry dust, river sand, compressive strength, water cement ratio, workability. 1. INTRODUCTION

    Get Price
  • COMPRESSIVE STRENGTH OF CONCRETE USING LATERITIC …

    COMPRESSIVE STRENGTH OF CONCRETE USING LATERITIC SAND AND QUARRY DUST AS FINE AGGREGATE Joseph O. Ukpata1, Maurice E. Ephraim2 and Godwin A. Akeke1 1Department of Civil Engineering, Cross River University of Technology, Calabar, Nigeria 2Department of Civil Engineering, Rivers State University of Science and Technology, Port Harcourt, Nigeria

    Get Price
  • Can we make concrete using quarry dust as a replacement ...

    Jul 01, 2017· Yes As quarry dust(also called as crushed sand) is a byproduct obtained after crushing of stones(rocks) to make aggregates. * Results have shown that the concrete ...

    Get Price
  • Experimental Investigation on the Effect of Replacement of ...

    Quarry dust can be used as an alternative to the river sand. Cost analysis shows that there is 40% savings if quarry dust is used instead of sand. Illangoan.R [2000] [1] has done a study on replacement of sand by quarry dust in concrete. The compressive strength of concrete with quarry dust …

    Get Price
  • USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT …

    2. Improvement in concrete strength and durability. 3. Use of waste material and reduction in quantity of use less material. 4. The physical and chemical properties of quarry dust satisfy the requirements of sand. 5. Use of quarry dust in concrete help in workability of concrete. 6. Quarry dust is a waste product from stone crushing

    Get Price
  • application of quarry dust in concrete construction - Flat

    Mix design has been developed for three grades using design an approach IS, ACI, USBR, RN.No.4 and BRITISH for both conventional concrete and quarry dust concrete. Tests were conducted on cubes and beams to study the strength of concrete made of Quarry Rock Dust and the results were compared with the Natural Sand Concrete.

    Get Price
  • An Experimental study on compressive strength of Quarry ...

    The compressive strength results of quarry dust concrete (cubes) were obtained where M20 grade of concrete with 10 percent increment up to 100 percent replacement of quarry dust is concentrated and the results are presented. The study aimed to observe the compressive strength properties of quarry dust by varying full percentage

    Get Price
  • STRENGTH AND DURABILITY STUDIES ON CONCRETE USING …

    4.1 Compressive Strength Figures 4 shows the relationship between the compressive strength of concrete for 7 days, 14 days and 28 days and type of mix made with quarry dust. From the table, it is inferred that the control mix and the mix M1 will give approximately equal strength in 7 days. For M2, the

    Get Price
  • Improved Concrete Properties Using Quarry Dust as ...

    Quarry dust has been proposed as an alternative to river sand that gives additional benefit to concrete. Quarry dust is known to increase the strength of concrete over concrete made with equal quantities of river sand. The Compressive strength of quarry dust concrete continues to increase with age for all the percentage of quarry dust contents.

    Get Price
  • Experimental study on high volume fly ash concrete made ...

    Aug 19, 2019· Compressive strength is decreased when increasing of fly ash content in cement concrete (50% and 75% is replaced by cement). 28 days cube compressive strength of 5% coir pith and 75% quarry dust replacement of sand concrete is 13.26% decreased to the conventional concrete cube. 56 days cube compressive strength of 5% coir pith and 75% quarry ...

    Get Price
  • Experimental Investigation on Self Compacting Concrete ...

    harden concrete compressive strength and split tensile strength values are determined. Attempts have been made to study the properties of such SCCs and to investigate the suitability of Quarry Dust to be used as partial replacement materials for sand in SCC. Index Terms — SCC, Fly Ash, Silica Fume, Quarry Dust,

    Get Price
  • Comparing the Compressive Strengths of Concrete Made …

    Comparing the compressive strengths of concrete made with river sand and quarry dust as fine aggregates Chijioke Chiemela1, Igwegbe talter1, Ibearugbulem Ogedi1, Okoye meter2, Oke Mong2 1Civil Engineering Department, Federal Polytechnic Nekede, Owerri, Imo State, Nigeria 2Mechanical Engineering Department, Federal Polytechnic Nekede Owerri Imo State, Nigeria

    Get Price
  • INFLUENCE OF QUARRY DUST ON COMPRESSIVE STRENGTH OF CONCRETE

    Objectives: In the present study, by-product of stone crushed, quarry dust is replaced as a fine aggregate with 20%, 30%, 40%, 50% replacement. Methods/Analysis: The fine aggregate is being replaced with fine aggregate and the compressive strength is

    Get Price
  • Partial Replacement of Sand by Quarry Dust in Concrete

    4. [5]According to the value of compressive strength collected, the value is high and it show that quarry dust suitable to use as sand replacement. All the value of compressive strength surpasses the minimum value of compressive strength for normal concrete that is 7N/mm . So, quarry dust can apply as sand replacement in

    Get Price
  • Compressive strength of concrete by Lateratic sand and ...

    May 12, 2013· This video is unavailable. Watch Queue Queue. Watch Queue Queue

    Get Price
  • Effect on Compressive Strength of Concrete Made with ...

    EBSCOhost serves thousands of libraries with premium essays, articles and other content including Effect on Compressive Strength of Concrete Made with Crusher Dust and Gravel. Get access to over 12 million other articles!

    Get Price
  • (PDF) Study on Compressive Strength of Quarry Dust as Fine ...

    This was followed by compression, split tensile and bending tests on cubes, cylinders and RC beams respectively to study the strength of concrete made of quarry rock dust. The results were ...

    Get Price
  • Stone Dust in Concrete: Effect on Compressive Strength

    found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete (Suribabu et al., 2015). In the present study it is proposed to investigate the optimum replacement of river sand with stone dust for concrete in term of compressive strength performance at 7 days and 28 days. II.

    Get Price